Customized Products
The special customized power equipment provided by the company mainly includes lighthouse unit, water pump unit, natural gas unit, lighthouse water pump integrated machine, high-speed mobile power station, container power station, etc.
Belt Power System
Belt Power System
Marine Silent Genset
The marine ultra quiet generator produced by our company has the characteristics of low noise, low fuel consumption, simple and convenient maintenance, etc. it is designed and produced according to the military standard and provides customized service.
Vehicle Silent Genset
The on-board ultra quiet generator set developed and produced by our company is mainly used in relevant special vehicles, and can provide customized service. The product is reliable in quality, low in noise, maintenance oriented, and highly humanized, and can compete with foreign brand products.
Super Silent Genset
The company's production of land ultra quiet generator sets, ultra quiet generator set applications and high noise requirements of the place, all products can compete with imported brands.
Diesel Silent Genset
The company's silent generator sets, silent generators using the most advanced European technology design, Seiko build. New appearance, high degree of humanization, noise control at the lowest level in the industry, price concessions, this product sells well in Europe and America, is your ideal choice.
Web Home

Current Location :Web Home>>

Technology Center

Failure to maintain

Customized Products
The special customized power equipment provided by the company mainly includes lighthouse unit, water pump unit, natural gas unit, lighthouse water pump integrated machine, high-speed mobile power station, container power station, etc.
Belt Power System
Belt Power System
Marine Silent Genset
The marine ultra quiet generator produced by our company has the characteristics of low noise, low fuel consumption, simple and convenient maintenance, etc. it is designed and produced according to the military standard and provides customized service.
Vehicle Silent Genset
The on-board ultra quiet generator set developed and produced by our company is mainly used in relevant special vehicles, and can provide customized service. The product is reliable in quality, low in noise, maintenance oriented, and highly humanized, and can compete with foreign brand products.
Super Silent Genset
The company's production of land ultra quiet generator sets, ultra quiet generator set applications and high noise requirements of the place, all products can compete with imported brands.
Diesel Silent Genset
The company's silent generator sets, silent generators using the most advanced European technology design, Seiko build. New appearance, high degree of humanization, noise control at the lowest level in the industry, price concessions, this product sells well in Europe and America, is your ideal choice.
Web Home

Technology Center >> Failure to maintain

Add Time: 2010-11-23

柴油发电机组水箱中冒气泡，一般是气缸中的高压气体窜入冷却水道造成的。窜气的原因及排除方法如下。　　１、未按规定力矩拧紧缸盖螺母。若力矩太小，缸盖没压紧，高压燃气就会窜入水道。应按规定力矩拧紧缸盖螺母，并定期重新拧紧。　　２、气缸垫使用时间过长，被冲坏或烧损，密封性变差，造成漏气。要更换新气缸垫。　　３、缸盖平面加工不平或变形，造成漏气。应磨削缸盖平面或更换缸盖。　　４、装配不当，造成缸套台肩处断裂而窜气。按规定方法换新缸套。　　５、缸套台肩高度不够或机体上台肩孔深度过大，造成缸套装入机体后，凸出机体平面高度不够，甚至下陷，燃气就会从台肩处窜入水道。因此，装配前应试装，检查凸出量，并保证其在允许范围内。

柴油发电机组安装时应注意的几个问题

Add Time: 2010-11-01

1、安装地点需通风良好，发电机端应有足够的进风口，柴油机端应有良好的出风口。出风口面积应大于水箱面积1.5倍以上。2、安装地的周围应保持清洁，避免在附近放置能产生酸性、碱性等腐蚀性气体和蒸汽的物品。有条件的应配置灭火装置。3、在室内使用，必须将排烟管道通导室外，管径必须≥消音器的出烟管直径，所接之管路的弯头不宜超过3个，以保证排烟畅通，并应将管子向下倾斜5-10度，避免雨水注入；若排气管时垂直向上安装的，则必须加装防雨罩。4、基础采用混凝土时，在安装时须用水平尺测其水平度，使机组固定于水平的基础上。机组与基础之间应有专用防震垫或用底脚螺栓。5、机组外壳必须有可靠的保护接地，对需要有中性点直接接地的发电机，则必须由专业人员进行中性接地，并配置防雷装置，...

康明斯柴油发电机组的使用要求

Add Time: 2010-11-01

康明斯柴油机是美国康明斯公司２０世纪８０年代产品，全系列有四缸和六缸两种机型。具有结构先进、动力强劲、经济性好、操作简便、维修方便和大修间隔长等优点，但该机型结构复杂，有别于其他国产机型，正确使用康明斯柴油机，可以提高其使用寿命。１正确执行初期走合的规定　　　　康明斯柴油机使用寿命、工作可靠性及经济性在一定程度上取决于柴油车辆使用初期的走合。用户在购买新车后，必须按照规定执行新车１５００～２５００ｋｍ的走合期(相当于折合１００ｈ)。走合期要求切勿超载和高速行驶(载质量不得超过额定质量的８０％，最高速度不超过４５ｋｍ／ｈ)，最大功率时工作时间不可超过５ｍｉｎ，走合期每１０ｈ应检查一次曲轴箱的油平面。新车走合是延长柴油机使用寿命的重...

柴油发电机保养细则

Add Time: 2010-11-01

柴油机保养程序：　　A 级保养　　一、每日：　　1)检查发电机工作日报。　　2)检查发电机：机油平面，冷却液平面。　　3)日检发电机有无损坏、掺漏，皮带是否松弛或磨损。　　二、每周：　　1)重复每日的A级检查。　　2)检查空气滤清器，清洁或更换空气滤清器芯子。　　3)放出燃油箱及燃油滤清器中的水或沉积物。　　4)检查水过滤器。　　5)检查起动蓄电池。　　6)起动发电机并检查有无影响。　　7)用空气枪及清水冼冷却器前后端的散热片。　　　　B 级保养　　1)重复A级每日和每周的检查。　　2)更换发电机机油。(机油更换周期为250小时或一个月)　　3)更换机油滤清器。(机油滤芯更换周期为250小时或一个月)　　4)更换燃油滤清器滤芯。(更换周期为25...

[ Total QTY:39 ] [ Each page QTY:5 ] [ 8 / 8 ]

First

5 6 7 8

End

Article Search

Inheritance Is Power

Random push